(CNN)Problems were reported on a Lion Air jet that crashed into the sea off Jakarta even after technicians replaced a sensor on board the aircraft, investigators said.

All 189 people on board Flight 610 died when the new Boeing 737 MAX 8 crashed into the sea on October 29, 13 minutes after taking off from Jakarta on a short flight to Pangkal Pinang on the Indonesian island of Bangka.
Investigators said the jet experienced problems on its last four flights — including, crucially, the flight that crashed, according to Soerjanto Tjahjono, the head of the National Transportation Safety Committee (KNKT).
    Boeing released an operational bulletin on Wednesday, warning all airlines about how to address any erroneous readings related to the AOA sensor. The Federal Aviation Administration (FAA) later issued its own directive that advised pilots about how to respond to similar problems.

    Search for voice recorder

    Almost two weeks after the crash, authorities are still searching for the plane’s cockpit voice recorder (CVR), which is believed to be buried under deep mud. If found, it should reveal what happened in the cockpit in the final seconds of the flight.
    Investigators are already examining the flight data recorder that was pulled off the sea bed, some 30 meters under water, on November 1.

      Lion Air black box recovered, officials say

    Problems with air speed indicators

    Investigators who analyzed the jet’s flight data recorder (FDR) after the October 29 crash said there were problems with the air speed indicator on the past three flights before the crash.
    The airspeed indicator is like a speedometer and tells the pilot how fast the plane is moving through the air. It does this by gathering data from the plane’s pitot tube and the static port, which essentially compare differentials in the air pressure to arrive at the plane’s speed and the altitude.
    After problems were reported with the air speed indicator, the AOA sensor was replaced by a Lion Air technician in Bali before the plane departed for Jakarta on its penultimate flight.
    Passengers on that flight told CNN that the plane experienced a significant drop in altitude shortly after takeoff. “After 10 minutes in the air the plane dropped as if it was losing power. People panicked. It dropped about 400 feet,” passenger Robbi Gaharu said.
    Once in Jakarta, a Lion Air technician checked the plane again and gave it the green light to fly on its final flight, from Jakarta to Pangkal Pinang.
    Lion Air Group Managing Director Captain Daniel Putut Kuncoro Adi told CNN on Wednesday that Lion Air strictly follows Boeing’s guidance for operatingthe737 MAX 8s, as laid out in the maintenance manual book.
    “Pilots write in the logbook about the problem they had in the flight, then our technicians fix it and write (what) they did in the logbook,” said the managing director, adding that technical conversations between pilots and technicians regarding the aircraft are written and signed in a document called the Aircraft Flight and Maintenance Log.
    Quest says investigators will be looking at a combination of factors that could have caused the crash.
    “A crash is always a series of events. Fundamentally the issue is going to be how those pilots flew the plane as the conditions arose,” he said.

    What does Boeing and the FAA say?

    On Wednesday, Boeing said it had issued an “Operations Manual Bulletin” advising airline operators how to address erroneous cockpit readings.
    A spokesperson for the aircraft manufacturer wouldn’t disclose to CNN whether the directive was issued to operators of all Boeing aircraft, or just those who fly 737 MAX 8 planes, the same model as Flight 610.
    The directive points operators “to existing flight crew procedures to address circumstances where there is erroneous input from an AOA sensor,” the statement said.
    Following Boeing’s bulletin, the Federal Aviation Administration (FAA) on Wednesday issued an airworthiness directive to Boeing 737 MAX 8 crews if they experience the same problems that brought down Lion Air Flight 610.
    “These erroneous inputs can potentially make the horizontal stabilizers repeatedly pitch the nose of the airplane downward, making the aircraft difficult to control,” the directive said.
    It continued that, “The FAA has alerted affected domestic carriers and foreign airworthiness authorities who oversee air carriers who use the 737 MAX.”
      The FAA directive does not acknowledge an issue with the entire fleet of 737 MAX 8 airplanes and there have been no reported comparable issues in the US.
      Boeing said it is involved in the ongoing investigation with KNKT and other government authorities into the Lion Air crash and “continues to cooperate fully and provide technical assistance.”

      Leave a Reply